Jump to content
Do Not Sell My Personal Information


Hilux engine vibration/drone?


hiluxguy
 Share

Recommended Posts

Hi,

So I have recently brought a manual 2006 Hilux, which is now creating a loud engine drone/ vibration.

It happens under load, between 1500 - 2000 rpm, only in gears 3, 4 and 5. It is the worse in 4th gear.

I have taken it to my mechanic, and he thought it would be the engine mounts, so I have replaced them, where nothing was resolved. Ive also recently had the diesel injectors replaced. I have had all new oil in the difs but the vibration is still there?

Does anyone have any idea where this vibration could be coming from??

 

Link to comment
Share on other sites

Hi Reece, if it only happens when in either 3rd, 4th and 5th that would suggest it is a gearbox problem or a bearing problem in the drive train, either one in the gearbox or wheel bearings.  As the vehicle picks up speed as the various parts pick up speed, and usually noises that cannot be heard at lower speeds indicate one of these things are at fault. Mike.

Link to comment
Share on other sites

Hi Mike, 

I also forgot to mention that it happens when I put into 4wd in second gear as well. Im not sure that makes any difference?

As soon as 2000rpm hits, the vibration will stop, and wont be heard again no matter what the speed is, unless the revs are between 1500 - 2000 rpm. 

The noise/ vibration will get louder the more i push the pedal to the floor. lightly pressing the pedal will result in little or no vibration.

Link to comment
Share on other sites

Hi Reece. It sounds to me you need to go to a garage that specialises in gearbox/drive train problems as they can put it on a ramp as it's much easier to hear a noise from underneath than from the drivers seat. Of course they will give you their free advise hoping to get some work from it then it's up to you if you give them the job or just tell them you'll take it away whilst you think about it once they start giving you estimates what they would want to fix it. Giving a diagnosis about noises from a computer is hard work, from being to hear it is much easier.......my suggestion is probably cheaper rather than you keep doing jobs that probably don't need doing, basically you get a free fault diagnosis and if you can do the job and don't mind getting dirty you can do it yourself of course you can give them the job if it's too much for you. You don't need a Toyota dealer to give the advise just Google to find a local transmission place that's close to where you live. Mike.

Link to comment
Share on other sites

  • 8 months later...

Hi Reece,

I hope you maybe able to help. I have the same problem with a 2009 Hilux. Did you manage to cure your vibration problem, if so what was the cause. Regards Kevin

 

Link to comment
Share on other sites


  • 1 month later...

Any update what the problem was, l have the exact same problem with my Hilux?

Link to comment
Share on other sites

I haven't been able to solve the vibration but I believe that it is coming from the gearbox. I have disconnected the rear drive shaft and tested it using the four wheel drive and it still vibrates. I am now learning to live with it. It would appear to only affect manual gearboxes. Good luck, should you be able to identify the cause could you let me know please.

Regards, Kevin

Link to comment
Share on other sites

  • 1 year later...

I have the same exactly problem on my 12 hilux and it started after i change my clutch kit.

Did anyone managed to fix it ? 
 

thanks in advance

Link to comment
Share on other sites

  • 1 year later...

Hi I have the last 2015 3ltr model and also have this noise has anyone found a solution to this . 

Link to comment
Share on other sites

  • 8 months later...

Hi, did anyone ever get to the bottom of this issue with vibration? I have a 2010 with a manual box now doing exactly the same thing after replacing the clutch.

any help would be appreciated .

Ricky

Link to comment
Share on other sites

  • 5 months later...

I have a 1998 KZTE Prado and doing the same thing, one person said after many years of struggling it was due to a non OEM clutch kit that cause the vibration, then another ex Toyota person said it will cost you alot to sort out but it is mainly due to old age off diesel engine and total lack of power before turbo kicks in. He said new OEM engine mounts only and upgrade exhaust  pipe to a 3inch unit and bigger baffle will reduce vibration with about 50%

I will do m y engine mounts first due to old age then exhaust system and will update.

Link to comment
Share on other sites

  • 1 month later...

Look at ya flywheel boys 🤪 

Brother inlaws is doing it also 😁 

Link to comment
Share on other sites

  • 1 year later...

Hi All, 

I have a 2018 Land Cruiser (EU model) and I have this also. Researching it seems it is a well known Toyota problem of a droning noise at 1500-2000 rpm and is caused by a resonance created by the air turbulence, between the inner wing and the inner mud guard, as the air cleaner draws air in...

https://www.pradopoint.com.au/forum/-150-series-discussion-the-2010-prado/general-150-series/13299-fixing-the-1500rpm-drone-vibration-and-rattles/page5?22876-Fixing-the-1500rpm-drone-vibration-and-rattles=

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

 Share





×
×
  • Create New...




Forums


News


Membership